Click here to make tpub.com your Home Page

Page Title: Home Page

• OPERATOR, ORGANIZATIONAL, DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL
• SAFETY PRECAUTIONS
• LUBRICATING AND SERVICING UNIT: POWER OPERATED; TRAILER MOUNTED, 23 CFM COMPRESSOR, RECIPROCATING GASOLINE DRIVEN
• Engine Assembly
• Figure 4-1. Continued
• LUBRICATING AND SERVICING UNIT: POWER OPERATED; TRAILER MOUNTED, 23 CFM COMPRESSOR, RECIPROCATING GASOLINE DRIVEN
• Warning
• LUBRICATING AND SERVICING UNIT: POWER OPERATED; TRAILER MOUNTED, 23 CFM COMPRESSOR, RECIPROCATING GASOLINE DRIVEN
• Table 2-0. Maintenance and Operating Supplies
• Table 2-0. Maintenance and Operating Supplies (Cont)
• Appendix B: Basic Issue Item List and Items tropp Installated or Authorized
• LUBRICATING AND SERVICING UNIT: POWER OPERATED; TRAILER MOUNTED, 23 CFM COMPRESSOR, RECIPROCATING GASOLINE DRIVEN
• Table 2-1. Lubricant Pump Peformance Data Chart
• Table of Contents
• Table of Contents (Cont)
• Chapter 1: INTRODUCTION
• Figure 1-1. Lubricating unit, right rear, view
• Figure 1-1. Lubricating unit, right rear, view (Cont)
• Identification and Tabulated Data
• Difference in Models
• Diagram
• Figure 1-3. Continued
• Figure 1-4. Lubrication hose diagram
• FIGURE 1-5. Air and Hydraulic schematic
• Chapter 2. INSTALLATION AND OPERATING INSTRUCTIONS
• FIgure 2-1. Unloading Lubricating unit
• Figure 2-2. Loading ramp construction
• Installation or Setting Up Instructions
• Controls and Instruments
• Figure 2-3. Operating Controls, Instruments and Major Component Location
• Controls and Instruments (Cont)
• Section IV. OPERATION OF EQUIPMENT
• Filling Lubricant Tanks
• FIGURE 2-5. Lower drawer assembly
• Dispensing Lubricants
• Shutdown Procedures
• Operation in Extreme Heat
• Section V. OPERATION OF MATERIAL USED IN CONJUNCTION WITH THE EQUIPMENT
• Pneumatic Gun
• Fire Extinguisher
• Figure 2-8. Alcohol dispenser assembly and master air valve
• Chapter 3: OPERATOR AND ORGANIZATIONAL MAINTENANCE INSTRUCTIONS
• Figure 3-2(1). Daily preventive maintenance services
• Figure 3-2 y -Continued.
• PREVENTIVE MAINTENANCE SERVICES QUARTERLY
• Figure 3-3 x . Quarterly preventive maintenance services..
• Section IV. OPERATOR'S MAINTENANCE
• Air Compressor
• Fuel Tank
• Figure 3-6. Lubrication unit-major components, exploded view.
• SECTION V. TROUBLESHOOTING
• Section VI. RADIO INTERFERENCE SUPPRESSION
• Section VIII. ENGINE ASSEMBLY
• Figure 3-7. Continued
• Section IX. FUEL SYSTEM
• Figure 3-8. Air lubrication system.
• Section X. EXHAUST SYSTEM
• Generator
• Figure 3-9. Reflectors, clearance lights, blackout tailight, and directional stop and tailight- removal and installation
• Stoplights-Directional and Tail, and Reflectors
• Safety Devices
• Section XIII. WHEELS, TIRES AND TUBES
• Wheel Bearings, Hub and Brakedrum
• Section XIV. SERVICE BRAKES, HYDRAULIC BRAKE SYSTEM, AND AIR BRAKE SYSTEM
• Figure 3-15. Service brake adjustment and bleeding.
• Service Brakes and Hydraulic Wheel Cylinder
• Brake Air Chamber
• Figure 3-18. Brake air chamber-disassembly and reassembly.
• Air Reservoir
• Landing Gear
• Shack Absorbers
• Spring Bumpers
• Fenders
• Safety Chains
• Section XVI. COMPRESSOR AND COMPONENTS
• Figure 3-26. Compressor flywheel and pulley, intercooler and lines, removal and installation
• Intercooler and lines
• Section XVII. HOSE REEL ASSEMBLIES AND CONTROLS (Used only on Serial Numbers 69-29737 thru 69-29942)
• Figure 3-28. High pressure chassis control (used only on Serial Numbers 9-29787 through 69-29942) .
• Figure 3-28. High pressure chassis control (used only on Serial Numbers 9-29787 through 69-29942) . (cont)
• Figure 3-29. Low pressure chassis control (used only on Serial Numbers 69-29737 through 69-29942).
• Section XVIII. HOSE REEL ASSEMBLIES (Used only on Units with Serial Number 84-29943 thru 84-30304 and 86-30305 thru 86-31248)
• Figure 3-31. Grease control valve
• Figure 3-31. Grease control valve
• Control Valve
• Pneumatic Gun
• Air Pressure Regulator, Fittings and Gage
• Section XX. AIR PRESSURE GAUGE, COMPRESSOR RELIEF VALVE, AND AIR RECEIVER TANK
• Section XXI. ALCOHOL DISPENSER, MASTER AIR VALVE, LINES AND FITTINGS
• Chapter 4: DIRECT AND GENERAL SUPPORT MAINTENANCE INSTRUCTIONS
• Chapter 5: GENERAL MAINTENANCE INSTRUCTIONS
• Section Ill. REMOVAL AND INSTALLATION OF MAJOR COMPONENTS AND AUXILIARIES
• Axle Assembly
• Air Tank Receiver
• Figure 5-3. Air tank receiver-removal and installation.
• Trailer Frame
• Chapter 6: ELECTRICAL COMPONENTS REPAIR INSTRUCTIONS
• Generator and Components
• Section Il. STARTER ASSEMBLY
• Starter
• Chapter 7: AIR COMPONENT REPAIR INSTRUCTIONS
• Figure 7-1. Compressor cylinder head
• FIgure 7-2. Compressor cylinders and pistons
• Figure 7-2. Compressor base assembly
• Section II. COMPRESSOR RELIEF VALVE
• Compressor Relief Valve
• Chapter 8: LUBRICATING EQUIPMENT REPAIR INSTRUCTIONS
• Figure 8-1. High pressure lubrication pump
• Low Pressure Pump
• Figure 8-2. Low pressure lubrication pump
• Section Il. LUBRICATING UNIT PUMPS AND VALVES
• Figure 8-3 x .High and low pvessure pumps
• Figure 8-3 x .High and low pvessure pumps (Cont)
• Figure 8-3 x .High and low pvessure pumps (Cont)
• High and Low Pressure Air Powered Pumps
• Figure 8-3 x .High and low pvessure pumps (Cont)
• Figure 8-3 x .High and low pvessure pumps (Cont)
• Figure 8-3 x .High and low pvessure pumps (Cont)
• Section Ill. TRANSFER PUMP
• Figure 8-4. Transfer pump
• Section IV. TRANSFER PUMP
• Figure 8-5. Transfer Pump
• Section V. HOSE REEL ASSEMBLIES
• Section VI. HOSE REEL ASSEMBLIES
• Figure 8-7. Chassis,gear and engine oil reels
• Section VII. ALCOHOL DISPENSER
• Figure 8-8. Alcohol dispenser - exploded view
• Chapter 9: HYDRAULIC BRAKE COMPONENTS
• Section Il. AIR RELAY VALVE
• Figure 9-2. Air relay valve.
• Base Skid
• Chapter 10: GENERAL MAINTENANCE
• Appendix A: REFERENCES
• Shipment and Limited Storage
• Appendix B: BASIC ISSUE ITEMS LIST AND MAINTENANCE AND OPERATING SUPPLIES
• Section II: Basic Issue Items
• Section III: Maintenance and Operating Supplies
• Appendix C: MAINTENANCE ALLOCATION CHART
• Section II. MAINTENANCE ALLOCATION CHART
• Section II. MAINTENANCE ALLOCATION CHART (Cont)
• Section II. MAINTENANCE ALLOCATION CHART (Cont)
• Section II. MAINTENANCE ALLOCATION CHART (Cont)
• Section IV. REMARKS
• INDEX
• INDEX (Cont)
• INDEX (Cont)
• THE METRIC SYSTEM AND EQUIVALENTS
• DISTRIBUTION:
• Blank Page
• TM-5-4930-217-14
• Recommended Changes To Equipment Technical Publications
• Distribution
• DISTRIBUTION:
• Recommended Changes To Equipment Technical Publications
• By Order of the Secretary of the Army:
• DISTRIBUTION
• Recommended Changes To Equipment Technical Publications