NOTES - CONTINUED:
Each
10. OIL SEPARATOR ELEMENT.
4. ENGINE. Oil is to be changed each
4,000 hours replace the oil separator ele-
time an engine oil change is directed by
ment.
AOAP laboratory. When AOAP laboratory
support is not available, change oil each
100 hours. Drain when oil is warm.
5. ENGINE OIL LEVEL CHECK. Engine
Do not attempt to clean the ele-
oil level should be between high and low
ment or r e - u s e t h e e l e m e n t
marks on dipstick (allow to set 5 minutes
because of its clean appearance.
before checking).
Metal salts are deposited on the
e l e m e n t as the oil is separated
6. ENGINE OIL FILTER. Filter is to be
f r o m the air. Pollution of metal
replaced each time an engine oil change
salts on the element will lower the
is directed by AOAP laboratory. After in-
flash point and can cause a fire in
stalling new filter element, fill crankcase,
the separator. Destroy used ele-
operate engine 5 minutes, check housing
ment to prevent accidental re-use.
for leaks, check crankcase oil level and
bring to full mark. When AOAP laboratory
11. The following is a list of lubricants
support is not available, install new filter
w i t h military symbols and applicable
element each 100 hours.
specification numbers.
7. OIL SEPARATOR LEVEL. Check level
each 10 hours.
MIL-L-2104
OE/HDO
MIL-G-10924
GAA
WARNING
MIL-L-46167
OEA
P-D-680
(SD), Type II
Do not remove dipstick while com-
p r e s s o r is in operation. Always
relieve the air system of all air
pressure before removing dipstick
to check oil level.
Copy of this Lubrication Order will remain
8. OIL SEPARATOR. Each 500 hours
with the equipment at all times, instruc-
change oil. Drain when lubricant is warm.
tions contained herein are mandatory.
After refill, operate for 5 minutes, check
for leaks and bring to full mark. Observe
warning given in Note 7.
By order of the Secretary of the Army:
9. COMPRESSOR OIL FILTER. Each 100
JOHN A. WICKHAM, JR.
hours, remove filter element, clean hous-
General, United States Army
ing and install new filter element. After in-
Chief of Staff
s t a l l i n g new filter element, fill com-
pressor, operate for 5 minutes, check for
OFFICIAL:
leaks and bring to full mark. Observe war-
ning given in Note 7.
ROBERT M. JOYCE
Major General, United States Army
The Adjutant General
DISTRIBUTION:
To be distributed in accordance with
DA Form 12-25A, Operator and Organi-
zational maintenance requirements for
Rotary Air Compressors.
TA 220100
CARD 4 OF 4
LO 5-4310-345-12
*U.S. GOVERNMENT PRINTING OFFICE. 1984 O--754-605
017985
