Chapter 1. INTRODUCTION - TM-5-4310-335-140008
Figure 1-1. Air Compressor
Tabulated Data - TM-5-4310-335-140010
Tabulated Data (cont)
Chapter 2. OPERATING INSTRUCTIONS - TM-5-4310-335-140012
Figure 2-1. Air Compressor, right hand view.
Figure 2-2. Air compressor, three-quarter rear view
Section II. OPERATION OF AUXILIARY EQUIPMENT - TM-5-4310-335-140015
Section IV. OPERATION UNDER UNUSUAL CONDITIONS - TM-5-4310-335-140016
Operation Under Sandy or Dusty Conditions
Protection of the Compressor
Chapter 3. OPERATOR'S MAINTENANCE INSTRUCTIONS - TM-5-4310-335-140019
Figure 3-1. Compressor Lubrication Chart (sheet 1 of 2).
Figure 3-1. Compressor Lubrication Chart (sheet 2 of 2).
Table 3-1. Preventive Maintenance Checks and Services
Table 3-2. TROUBLESHOOTING - TM-5-4310-335-140023
Chapter 4. ORGANIZATIONAL MAINTENANCE INSTRUCTIONS - TM-5-4310-335-140024
Table 4-1. Organizational Preventive Maintenance Checks and Services - TM-5-4310-335-140025
Section IV. TROUBLESHOOTING - TM-5-4310-335-140026
Table 4-2. TROUBLESHOOTING - TM-5-4310-335-140027
ENGINE STARTS BUT FAILS TO CONTINUE RUNNING
ENGINE MISSES OR RUNS ERRATICALLY
ENGINE SURGES OR OVERSPEEDS
Section VI. MAINTENANCE OF FUEL TANK
Moisture Separator and Sphere Safety Cap Tape
Section VIII. MAINTENANCE OF COMPRESSOR/COOLER ASSEMBLY
Section IX. MAINTENANCE OF AXLES, BRAKES, AND WHEELS
Figure 4-2. Tire wheel and hub assembly
Brakes Assembly
Cleaning, Inspection and Repair. - TM-5-4310-335-140037
Chapter 5. DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE INSTRUCTIONS - TM-5-4310-335-140038
Table 5-1. TROUBLESHOOTING - TM-5-4310-335-140039
Table 5-1. TROUBLESHOOTING (Continued)
ENGINE OIL CONSUMPTION EXCESSIVE
ENGINE EXCESSIVELY NOISY
LOW FLOW OR LONG FILL TIME (COMPRESSOR)
LOW OIL PRESSURE (COMPRESSOR)
OIL LEAKAGE
Table 5-2. Recommended Wrench Torques and Tolerances
Figure 5-1. Roof Assembly
Figure 5-2. Dehydrator
Figure 5-3. Moisture Separator
Figure 5-4. Sphere
Engine Assembly - TM-5-4310-335-140051
Figure 5-5. Air Compressor Assembly
Figure 5-6. Engine and Compressor Assembly (Sheet 1 of 2).
Figure 5-6. Engine and Compressor Assembly (sheet 1 of 2) (Continued).
Figure 5-6. Engine and Compressor Assembly (sheet 2 of 2) (Continued)
Table 5-6. Engine and Compressor Assembly (sheet 2 of 2) (Continued)
Compressor/Cooler
Chapter 6. REPAIR OF ROOF ASSEMBLY AND PNEUMATIC SYSTEM ACCESSORIES
Figure 6-1. Roof Assembly (Sheet 1 of 2)
Figure 6-1. Roof Assembly (Sheet 1 of 2) (Continued).
Figure 6-1. Roof Assembly (Sheet 2 of 2)
Figure 6-1. Roof Assembly (Sheet 2 of 2) (Continued).
Figure 6-2. Fuel Tank Assembly
Figure 6-3. Charging Chuck Assembly
Figure 6-4. Heater Cable Assembly
Roof Assembly Components.
Section II. PNEUMATIC SYSTEM ACCESSORIES
Figure 6-5. Dehydrator Assembly
Cleaning - TM-5-4310-335-140069
Figure 6-6. Moisture Separator Assembly
Sphere Assembly
Figure 6-7. Sphere Assembly Components
Figure 6-8. Sphere Relief Valve
Figure 6-9. Back Pressure Valve Assembly
Figure 6-10. Check Valve Assembly
Figure 6-11. Timer Box Assembly
Figure 6-12. Unloader Valve Assembly
Timer Box Assembly
Figure 6-13. Timer Box Control Setting Setup.
Figure 6-14. Unloader Valve Setting and Testing Setup.
Unloader Valve Assembly
Chapter 7. REPAIR OF COMPRESSOR/COOLER ASSEMBLY AND FRAME
Figure 7-1. Intercoolers, Fan and Lubrication Lines
Figure 7-2. Oil Lines and Mounting Hardware.
Figure 7-3. First Stage Relief Valve
Figure 7-5. Third Stage Relief Valve
Figure 7-6. Aftercooler, Relief Lines and Mounting Hardware
Figure 7-7. Fourth Stage Relief Valve
Third Stage Relief Valve
Section II. FRAME ASSEMBLY
Figure 7-8. Frame Assembly
Assembly. - TM-5-4310-335-140092
Appendix A. REFERENCES - TM-5-4310-335-140093
Fire Protection and Safety
Appendix B. MAINTENANCE ALLOCATION CHART - TM-5-4310-335-140095
SECTION II. MAINTENANCE ALLOCATION CHART - TM-5-4310-335-140096
SECTION II. MAINTENANCE ALLOCATION CHART (cont) - TM-5-4310-335-140097
SECTION II. MAINTENANCE ALLOCATION CHART (cont) - TM-5-4310-335-140098
TM-5-4310-335-14 Compressor Reciprocating Air Wheel Mounted 2 Wheel Pneumatic Tires: GED 4 CFM 3000 PSI (210 9000 kgs per sq cm) Manual
Figure 1-1. Air Compressor
Tabulated Data - TM-5-4310-335-140010
Tabulated Data (cont)
Chapter 2. OPERATING INSTRUCTIONS - TM-5-4310-335-140012
Figure 2-1. Air Compressor, right hand view.
Figure 2-2. Air compressor, three-quarter rear view
Section II. OPERATION OF AUXILIARY EQUIPMENT - TM-5-4310-335-140015
Section IV. OPERATION UNDER UNUSUAL CONDITIONS - TM-5-4310-335-140016
Operation Under Sandy or Dusty Conditions
Protection of the Compressor
Chapter 3. OPERATOR'S MAINTENANCE INSTRUCTIONS - TM-5-4310-335-140019
Figure 3-1. Compressor Lubrication Chart (sheet 1 of 2).
Figure 3-1. Compressor Lubrication Chart (sheet 2 of 2).
Table 3-1. Preventive Maintenance Checks and Services
Table 3-2. TROUBLESHOOTING - TM-5-4310-335-140023
Chapter 4. ORGANIZATIONAL MAINTENANCE INSTRUCTIONS - TM-5-4310-335-140024
Table 4-1. Organizational Preventive Maintenance Checks and Services - TM-5-4310-335-140025
Section IV. TROUBLESHOOTING - TM-5-4310-335-140026
Table 4-2. TROUBLESHOOTING - TM-5-4310-335-140027
ENGINE STARTS BUT FAILS TO CONTINUE RUNNING
ENGINE MISSES OR RUNS ERRATICALLY
ENGINE SURGES OR OVERSPEEDS
Section VI. MAINTENANCE OF FUEL TANK
Moisture Separator and Sphere Safety Cap Tape
Section VIII. MAINTENANCE OF COMPRESSOR/COOLER ASSEMBLY
Section IX. MAINTENANCE OF AXLES, BRAKES, AND WHEELS
Figure 4-2. Tire wheel and hub assembly
Brakes Assembly
Cleaning, Inspection and Repair. - TM-5-4310-335-140037
Chapter 5. DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE INSTRUCTIONS - TM-5-4310-335-140038
Table 5-1. TROUBLESHOOTING - TM-5-4310-335-140039
Table 5-1. TROUBLESHOOTING (Continued)
ENGINE OIL CONSUMPTION EXCESSIVE
ENGINE EXCESSIVELY NOISY
LOW FLOW OR LONG FILL TIME (COMPRESSOR)
LOW OIL PRESSURE (COMPRESSOR)
OIL LEAKAGE
Table 5-2. Recommended Wrench Torques and Tolerances
Figure 5-1. Roof Assembly
Figure 5-2. Dehydrator
Figure 5-3. Moisture Separator
Figure 5-4. Sphere
Engine Assembly - TM-5-4310-335-140051
Figure 5-5. Air Compressor Assembly
Figure 5-6. Engine and Compressor Assembly (Sheet 1 of 2).
Figure 5-6. Engine and Compressor Assembly (sheet 1 of 2) (Continued).
Figure 5-6. Engine and Compressor Assembly (sheet 2 of 2) (Continued)
Table 5-6. Engine and Compressor Assembly (sheet 2 of 2) (Continued)
Compressor/Cooler
Chapter 6. REPAIR OF ROOF ASSEMBLY AND PNEUMATIC SYSTEM ACCESSORIES
Figure 6-1. Roof Assembly (Sheet 1 of 2)
Figure 6-1. Roof Assembly (Sheet 1 of 2) (Continued).
Figure 6-1. Roof Assembly (Sheet 2 of 2)
Figure 6-1. Roof Assembly (Sheet 2 of 2) (Continued).
Figure 6-2. Fuel Tank Assembly
Figure 6-3. Charging Chuck Assembly
Figure 6-4. Heater Cable Assembly
Roof Assembly Components.
Section II. PNEUMATIC SYSTEM ACCESSORIES
Figure 6-5. Dehydrator Assembly
Cleaning - TM-5-4310-335-140069
Figure 6-6. Moisture Separator Assembly
Sphere Assembly
Figure 6-7. Sphere Assembly Components
Figure 6-8. Sphere Relief Valve
Figure 6-9. Back Pressure Valve Assembly
Figure 6-10. Check Valve Assembly
Figure 6-11. Timer Box Assembly
Figure 6-12. Unloader Valve Assembly
Timer Box Assembly
Figure 6-13. Timer Box Control Setting Setup.
Figure 6-14. Unloader Valve Setting and Testing Setup.
Unloader Valve Assembly
Chapter 7. REPAIR OF COMPRESSOR/COOLER ASSEMBLY AND FRAME
Figure 7-1. Intercoolers, Fan and Lubrication Lines
Figure 7-2. Oil Lines and Mounting Hardware.
Figure 7-3. First Stage Relief Valve
Figure 7-5. Third Stage Relief Valve
Figure 7-6. Aftercooler, Relief Lines and Mounting Hardware
Figure 7-7. Fourth Stage Relief Valve
Third Stage Relief Valve
Section II. FRAME ASSEMBLY
Figure 7-8. Frame Assembly
Assembly. - TM-5-4310-335-140092
Appendix A. REFERENCES - TM-5-4310-335-140093
Fire Protection and Safety
Appendix B. MAINTENANCE ALLOCATION CHART - TM-5-4310-335-140095
SECTION II. MAINTENANCE ALLOCATION CHART - TM-5-4310-335-140096
SECTION II. MAINTENANCE ALLOCATION CHART (cont) - TM-5-4310-335-140097
SECTION II. MAINTENANCE ALLOCATION CHART (cont) - TM-5-4310-335-140098
TM-5-4310-335-14 Compressor Reciprocating Air Wheel Mounted 2 Wheel Pneumatic Tires: GED 4 CFM 3000 PSI (210 9000 kgs per sq cm) Manual
