Chapter 1. INTRODUCTION - TM-5-4310-370-140007
FIGURE 1-1. COMPONENT IDENTIFICATION - TM-5-4310-370-140008
Section III. TECHNICAL PRINCIPLES OF OPERATION - TM-5-4310-370-140009
MINOR COMPONENTS AND ACCESSORIES
Chapter 2. OPERATING INSTRUCTIONS - TM-5-4310-370-140011
FIGURE 2-1. OPERATORS CONTROLS AND INDICATORS - TM-5-4310-370-140012
TABLE 2-1. OPERATOR/CREW PREVENTIVE CHECKS AND SERVICES - TM-5-4310-370-140013
Section III. OPERATION UNDER USUAL CONDITIONS - TM-5-4310-370-140014
Section IV. OPERATION UNDER UNUSUAL CONDITIONS - TM-5-4310-370-140015
OPERATION IN DUSTY OR SANDY AREAS. - TM-5-4310-370-140016
Chapter 3. OPERATION MAINTENANCE INSTRUCTIONS - TM-5-4310-370-140017
FIGURE 3-1. LUBRICATION CHART - TM-5-4310-370-140018
Section II. OPERATOR/CREW TROUBLESHOOTING
TABLE 3-1. OPERATOR/CREW TROUBLESHOOTING - TM-5-4310-370-140020
MOTOR IS RUNNING, BUT COMPRESSOR PUMP IS NOT
V BELT BREAKAGE - TM-5-4310-370-140022
Section III. MAINTENANCE PROCEDURES - TM-5-4310-370-140023
DAILY DRAINING OF AIR RECEIVER - TM-5-4310-370-140024
FIGURE 3-4. AIR RECEIVER AIR RELEASE
GLOBE VALVE USE
FIGURE 3-7. INFLATOR GAGE HOSE CONNECTION
FIGURE 3-8. AIR INLET FILTER REPLACEMENT - TM-5-4310-370-140028
Chapter 4. ORGANIZATIONAL MAINTENANCE - TM-5-4310-370-140029
FIGURE 4-1. WIRING DIAGRAM
Section II. ORGANIZATIONAL TROUBLESHOOTING
TABLE 4-1. ORGANIZATIONAL TROUBLESHOOTING - TM-5-4310-370-140032
KNOCKING OR RATTLE DEVELOPS IN COMPRESSOR PUMP - TM-5-4310-370-140033
EXCESSIVE OIL CONSUMPTION - TM-5-4310-370-140034
Section III. MAINTENANCE PROCEDURES - TM-5-4310-370-140035
STARTER SWITCH - MOTOR DISCONNECT. - TM-5-4310-370-140036
MOTOR REPLACEMENT. - TM-5-4310-370-140037
PRESSURE SWITCH ADJUSTMENT.
FIGURE 4-4. MOTOR REMOVAL AND REPLACEMENT - TM-5-4310-370-140039
COMPRESSOR PUMP REPLACEMENT.
FIGURE 4-6. COMPRESSOR PUMP REMOVAL AND REPLACEMENT - TM-5-4310-370-140041
REMOVAL AND REPLACEMENT OF PRESSURE GAGE. - TM-5-4310-370-140042
CHECK VALVE REPLACEMENT.
GLOBE VALVE REPLACEMENT.
INFLATOR GAGE HOSE REPLACEMENT.
INFLATOR GAGE REPLACEMENT.
FIGURE 4-12. INFLATOR GAGE REPLACEMENT - TM-5-4310-370-140047
Chapter 5. DIRECT AND GENERAL SUPPORT MAINTENANCE - TM-5-4310-370-140048
TABLE 5-1. DIRECT AND GENERAL SUPPORT TROUBLESHOOTING - TM-5-4310-370-140049
MOTOR DOES NOT START AT LOW OPERATING POINT OR DOES NOT STOP AT HIGH OPERATING POINT - TM-5-4310-370-140050
LOW DISCHARGE PRESSURE
COMPRESSOR PUMP OVERHEATING - TM-5-4310-370-140052
SAFETY VALVE RELEASES AIR BELOW WORKING PRESSURE OF 195 PSI (1350 KPa) - TM-5-4310-370-140053
MOTOR INCAPABLE OF TURNING COMPRESSOR PUMP - TM-5-4310-370-140054
Table 5-2. COMPRESSOR PUMP OVERHAUL REPLACEMENT STANDARDS - TM-5-4310-370-140055
Section II. MAINTENANCE PROCEDURES - TM-5-4310-370-140056
FIGURE 5-1. MOTOR ASSEMBLY
Motor Reassembly
Starter Switch Replacement
INTERCOOLER TUBE AND HEAD ASSEMBLIES DISASSEMBLY
FIGURE 5-2. STARTER SWITCH REPLACEMENT - TM-5-4310-370-140061
FIGURE 5-3. PRESSURE SWITCH REPLACEMENT - TM-5-4310-370-140062
FIGURE 5-4. INTERCOOLER TUBE REMOVAL
FIGURE 5-5. HEAD ASSEMBLIES REMOVAL
FIGURE 5-6. HIGH PRESSURE HEAD ASSEMBLY
CYLINDERS, PISTONS ASSEMBLIES, AND CONNECTING ROD ASSEMBLY DISASSEMBLY.
FIGURE 5-8. CYLINDER REMOVAL AND REPLACEMENT
CRANKCASE DISASSEMBLY
FIGURE 5-9. PISTON AND ROD ASSEMBLIES
CRANKCASE REASSEMBLY.
CYLINDER, PISTON ASSEMBLIES, AND CONNECTING ROD ASSEMBLIES REASSEMBLY.
INTERCOOLER TUBE ASSEMBLY AND HEAD ASSEMBLIES REASSEMBLY.
SAFETY RELIEF VALVE TESTING AND REPLACEMENT.
Appendix A. REFERENCES - TM-5-4310-370-140074
Appendix B. MAINTENANCE ALLOCATION CHART - TM-5-4310-370-140075
COLUMN ENTRIES USED IN THE MAC. - TM-5-4310-370-140076
Section II. MAINTENANCE ALLOCATION CHART (MAC) - TM-5-4310-370-140077
Section II. MAINTENANCE ALLOCATION CHART (MAC) (Cont'd) - TM-5-4310-370-140078
Appendix C. COMPONENTS OF END ITEMS LIST - TM-5-4310-370-140079
Section II. INTEGRAL COMPONENTS OF END ITEM - TM-5-4310-370-140080
Appendix D. ADDITIONAL AUTHORIZATION LIST - TM-5-4310-370-140081
Appendix E. EXPENDABLE SUPPLIES AND MATERIALS LIST - TM-5-4310-370-140082
Section II. EXPENDABLE SUPPLIES AND MATERIALS LIST - TM-5-4310-370-140083
TM-5-4310-370-14 Compressor Unit Reciprocating Electric 5 CFM 175 PSI (4310-01-089-4330) Manual
FIGURE 1-1. COMPONENT IDENTIFICATION - TM-5-4310-370-140008
Section III. TECHNICAL PRINCIPLES OF OPERATION - TM-5-4310-370-140009
MINOR COMPONENTS AND ACCESSORIES
Chapter 2. OPERATING INSTRUCTIONS - TM-5-4310-370-140011
FIGURE 2-1. OPERATORS CONTROLS AND INDICATORS - TM-5-4310-370-140012
TABLE 2-1. OPERATOR/CREW PREVENTIVE CHECKS AND SERVICES - TM-5-4310-370-140013
Section III. OPERATION UNDER USUAL CONDITIONS - TM-5-4310-370-140014
Section IV. OPERATION UNDER UNUSUAL CONDITIONS - TM-5-4310-370-140015
OPERATION IN DUSTY OR SANDY AREAS. - TM-5-4310-370-140016
Chapter 3. OPERATION MAINTENANCE INSTRUCTIONS - TM-5-4310-370-140017
FIGURE 3-1. LUBRICATION CHART - TM-5-4310-370-140018
Section II. OPERATOR/CREW TROUBLESHOOTING
TABLE 3-1. OPERATOR/CREW TROUBLESHOOTING - TM-5-4310-370-140020
MOTOR IS RUNNING, BUT COMPRESSOR PUMP IS NOT
V BELT BREAKAGE - TM-5-4310-370-140022
Section III. MAINTENANCE PROCEDURES - TM-5-4310-370-140023
DAILY DRAINING OF AIR RECEIVER - TM-5-4310-370-140024
FIGURE 3-4. AIR RECEIVER AIR RELEASE
GLOBE VALVE USE
FIGURE 3-7. INFLATOR GAGE HOSE CONNECTION
FIGURE 3-8. AIR INLET FILTER REPLACEMENT - TM-5-4310-370-140028
Chapter 4. ORGANIZATIONAL MAINTENANCE - TM-5-4310-370-140029
FIGURE 4-1. WIRING DIAGRAM
Section II. ORGANIZATIONAL TROUBLESHOOTING
TABLE 4-1. ORGANIZATIONAL TROUBLESHOOTING - TM-5-4310-370-140032
KNOCKING OR RATTLE DEVELOPS IN COMPRESSOR PUMP - TM-5-4310-370-140033
EXCESSIVE OIL CONSUMPTION - TM-5-4310-370-140034
Section III. MAINTENANCE PROCEDURES - TM-5-4310-370-140035
STARTER SWITCH - MOTOR DISCONNECT. - TM-5-4310-370-140036
MOTOR REPLACEMENT. - TM-5-4310-370-140037
PRESSURE SWITCH ADJUSTMENT.
FIGURE 4-4. MOTOR REMOVAL AND REPLACEMENT - TM-5-4310-370-140039
COMPRESSOR PUMP REPLACEMENT.
FIGURE 4-6. COMPRESSOR PUMP REMOVAL AND REPLACEMENT - TM-5-4310-370-140041
REMOVAL AND REPLACEMENT OF PRESSURE GAGE. - TM-5-4310-370-140042
CHECK VALVE REPLACEMENT.
GLOBE VALVE REPLACEMENT.
INFLATOR GAGE HOSE REPLACEMENT.
INFLATOR GAGE REPLACEMENT.
FIGURE 4-12. INFLATOR GAGE REPLACEMENT - TM-5-4310-370-140047
Chapter 5. DIRECT AND GENERAL SUPPORT MAINTENANCE - TM-5-4310-370-140048
TABLE 5-1. DIRECT AND GENERAL SUPPORT TROUBLESHOOTING - TM-5-4310-370-140049
MOTOR DOES NOT START AT LOW OPERATING POINT OR DOES NOT STOP AT HIGH OPERATING POINT - TM-5-4310-370-140050
LOW DISCHARGE PRESSURE
COMPRESSOR PUMP OVERHEATING - TM-5-4310-370-140052
SAFETY VALVE RELEASES AIR BELOW WORKING PRESSURE OF 195 PSI (1350 KPa) - TM-5-4310-370-140053
MOTOR INCAPABLE OF TURNING COMPRESSOR PUMP - TM-5-4310-370-140054
Table 5-2. COMPRESSOR PUMP OVERHAUL REPLACEMENT STANDARDS - TM-5-4310-370-140055
Section II. MAINTENANCE PROCEDURES - TM-5-4310-370-140056
FIGURE 5-1. MOTOR ASSEMBLY
Motor Reassembly
Starter Switch Replacement
INTERCOOLER TUBE AND HEAD ASSEMBLIES DISASSEMBLY
FIGURE 5-2. STARTER SWITCH REPLACEMENT - TM-5-4310-370-140061
FIGURE 5-3. PRESSURE SWITCH REPLACEMENT - TM-5-4310-370-140062
FIGURE 5-4. INTERCOOLER TUBE REMOVAL
FIGURE 5-5. HEAD ASSEMBLIES REMOVAL
FIGURE 5-6. HIGH PRESSURE HEAD ASSEMBLY
CYLINDERS, PISTONS ASSEMBLIES, AND CONNECTING ROD ASSEMBLY DISASSEMBLY.
FIGURE 5-8. CYLINDER REMOVAL AND REPLACEMENT
CRANKCASE DISASSEMBLY
FIGURE 5-9. PISTON AND ROD ASSEMBLIES
CRANKCASE REASSEMBLY.
CYLINDER, PISTON ASSEMBLIES, AND CONNECTING ROD ASSEMBLIES REASSEMBLY.
INTERCOOLER TUBE ASSEMBLY AND HEAD ASSEMBLIES REASSEMBLY.
SAFETY RELIEF VALVE TESTING AND REPLACEMENT.
Appendix A. REFERENCES - TM-5-4310-370-140074
Appendix B. MAINTENANCE ALLOCATION CHART - TM-5-4310-370-140075
COLUMN ENTRIES USED IN THE MAC. - TM-5-4310-370-140076
Section II. MAINTENANCE ALLOCATION CHART (MAC) - TM-5-4310-370-140077
Section II. MAINTENANCE ALLOCATION CHART (MAC) (Cont'd) - TM-5-4310-370-140078
Appendix C. COMPONENTS OF END ITEMS LIST - TM-5-4310-370-140079
Section II. INTEGRAL COMPONENTS OF END ITEM - TM-5-4310-370-140080
Appendix D. ADDITIONAL AUTHORIZATION LIST - TM-5-4310-370-140081
Appendix E. EXPENDABLE SUPPLIES AND MATERIALS LIST - TM-5-4310-370-140082
Section II. EXPENDABLE SUPPLIES AND MATERIALS LIST - TM-5-4310-370-140083
TM-5-4310-370-14 Compressor Unit Reciprocating Electric 5 CFM 175 PSI (4310-01-089-4330) Manual
