TM-5-4310-378-14 Compressor Unit Reciprocating 5 CFM 175 PSI Gasoline Engine Driven Hand Truck Mounted Model Number Manual

Chapter 1. INTRODUCTION - TM-5-4310-378-140017
FIGURE - TM-5-4310-378-140018
Section II. EQUIPMENT DESCRIPTION - TM-5-4310-378-140019
IDENTIFICATION - TM-5-4310-378-140020
EQUIPMENT DATA - TM-5-4310-378-140021
FIGURE - TM-5-4310-378-140022
Section III. Technical Principles of Operation - TM-5-4310-378-140023
Air Compressor - TM-5-4310-378-140024
Chapter 2. Operating Instructions - TM-5-4310-378-140025
Table 2-1. Compressor Assembly Controls and Indicator
FIGURE - TM-5-4310-378-140027
SECTION II. OPERATOR'S PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) - TM-5-4310-378-140028
Table 2-2. Operator Preventive Maintenance Checks and Services
Table 2-2. Operator Preventive Maintenance Checks and Services (Continued) - TM-5-4310-378-140030
Table 2-2. Operator Preventive Maintenance Checks and Services (Continued) - TM-5-4310-378-140031
Section III. OPERATION UNDER USUAL CONDITIONS - TM-5-4310-378-140032
STARTING - TM-5-4310-378-140033
STARTING (cont.) - TM-5-4310-378-140034
STARTING (cont.) - TM-5-4310-378-140035
OPERATION
Section IV. OPERATION UNDER UNUSUAL CONDITIONS - TM-5-4310-378-140037
OPERATING IN EXTREME COLD
OPERATION IN EXTREME HEAT - TM-5-4310-378-140039
OPERATION UNDER RAINY OR HUMID CONDITIONS - TM-5-4310-378-140040
Chapter 3. UNIT MAINTENANCE INSTRUCTIONS - TM-5-4310-378-140041
COMPRESSOR LUBRICATION PROCEDURE.
ENGINE LUBRICATION PROCEDURE
WHEEL BEARING LUBRICATION PROCEDURE
Section II. REPAIR PARTS, SPECIAL TOOLS, TMDE, AND SUPPORT EQUIPMENT - TM-5-4310-378-140045
Section IV. PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) - TM-5-4310-378-140046
Table 3-1. Unit Preventive Maintenance Checks and Services
Table 3-1. Unit Preventive Maintenance Checks and Services (Continued) - TM-5-4310-378-140048
Table 3-1. Unit Preventive Maintenance Checks and Services (Continued) - TM-5-4310-378-140049
Section V. TROUBLESHOOTING - TM-5-4310-378-140052
Table 3-2. Unit Maintenance Troubleshooting
SECTION VI. MAINTENANCE PROCEDURES
Installation. - TM-5-4310-378-140055
MATCHED SET V-BELTS
DRIVE PULLEY
COMPRESSOR ASSEMBLY - TM-5-4310-378-140058
TUBE ASSEMBLIES - TM-5-4310-378-140059
Inspection. - TM-5-4310-378-140060
INTERSTAGE RELIEF VALVE
COMPRESSOR AIR CLEANER - TM-5-4310-378-140062
Installation. - TM-5-4310-378-140063
OIL FILLER CAP AND SIGHT GLASS
Inspection. - TM-5-4310-378-140065
UNLOADER VALVE ASSEMBLIES
ENGINE ASSEMBLY - TM-5-4310-378-140067
Inspection. - TM-5-4310-378-140068
FUEL TANK AND FUEL FILTER ASSEMBLIES
Service.
Replacement. - TM-5-4310-378-140071
DUCTS COVERS AND DEFLECTORS
Replacement - TM-5-4310-378-140073
FLYWHEEL - TM-5-4310-378-140074
ENGINE IGNITION COIL
Replacement - TM-5-4310-378-140076
IGNITION SWITCH
SPARKPLUG
ENGINE AIR CLEANER - TM-5-4310-378-140079
Replacement. - TM-5-4310-378-140080
AIR CLEANER ELEMENT
Inspection - TM-5-4310-378-140082
Replacement - TM-5-4310-378-140083
FIGURE - TM-5-4310-378-140084
GOVERNOR ROD ASSEMBLY
GOVERNOR CONTROL ASSEMBLY - TM-5-4310-378-140087
RECOIL STARTER ASSEMBLY
Replacement. - TM-5-4310-378-140090
Figure 9. Recoil Starter Assembly
Repair. - TM-5-4310-378-140092
CYLINDER HEAD AND GASKET
OIL DIPSTICK AND GASKET
AFTERCOOLER ASSEMBLY
Replacement. - TM-5-4310-378-140096
SAFETY/PILOT VALVE
DRAIN VALVE
PRESSURE GAGE - TM-5-4310-378-140099
TANK RELIEF VALVE
AIR TANK - TM-5-4310-378-140101
AIR DISCHARGE HOSE
INFLATOR GAGE
WHEELS
TIRES AND TUBES
BELT IDLER ASSEMBLY
Section VII. PREPARATION FOR STORAGE OR SHIPMENT - TM-5-4310-378-140107
Chapter 4. INTERMEDIATE DIRECT SUPPORT MAINTENANCE INSTRUCTIONS - TM-5-4310-378-140109
Table 4-1. Intermediate Direct Support Maintenance Troubleshooting.
LITTLE OR NO AIR PRESSURE BUILDUP. - TM-5-4310-378-140111
ENGINE DIFFICULT TO START.
ENGINE STOPS.
Section ll. Maintenance Procedures.
COMPRESSOR CYLINDER HEADS AND VALVES
REPLACEMENT - TM-5-4310-378-140116
COMPRESSOR PISTONS, CONNECTING RODS, AND CYLINDERS
Replacement. - TM-5-4310-378-140118
Installation - TM-5-4310-378-140119
Repair - TM-5-4310-378-140120
COMPRESSOR CRANKSHAFT, BEARINGS, OIL SEALS, AND CRANKCASE
Removal - TM-5-4310-378-140122
Installation - TM-5-4310-378-140123
ENGINE ASSEMBLY - TM-5-4310-378-140124
ENGINE GOVERNOR AND CONTROL ASSEMBLY - TM-5-4310-378-140125
ENGINE GOVERNOR AND CONTROL ASSEMBLY - TM-5-4310-378-140127
AIR TANK - TM-5-4310-378-140128
FIGURE - TM-5-4310-378-140129
CHAPTER 5. INTERMEDIATE GENERAL SUPPORT MAINTENANCE INSTRUCTIONS
AIR COMPRESSOR OVERHAUL
OVERHAUL - TM-5-4310-378-140133
OVERHAUL (CONT) - TM-5-4310-378-140134
Inspect - TM-5-4310-378-140135
REPAIR - TM-5-4310-378-140136
OVERHAUL (CONT) - TM-5-4310-378-140137
OVERHAUL (CONT) - TM-5-4310-378-140138
APPENDIX A. REFERENCES - TM-5-4310-378-140139
APPENDIX B. MAINTENANCE ALLOCATION CHART - TM-5-4310-378-140141
EXPLANATION OF COLUMNS IN THE MAC, SECTION II - TM-5-4310-378-140142
EXPLANATION OF COLUMNS IN TOOL AND TEST EQUIPMENT REQUIREMENTS - TM-5-4310-378-140143
Section II. MAINTENANCE ALLOCATION CHART - TM-5-4310-378-140144
Section II. MAINTENANCE ALLOCATION CHART (CONT) - TM-5-4310-378-140145
Section II. MAINTENANCE ALLOCATION CHART (CONT) - TM-5-4310-378-140146
Section II. MAINTENANCE ALLOCATION CHART (CONT) - TM-5-4310-378-140147
SECTION III. TOOL AND TEST EQUIPMENT REQUIREMENTS - TM-5-4310-378-140148
APPENDIX C. COMPONENT OF END lTEM AND BASIC ISSUE ITEMS LISTS
SECTION II. COMPONENTS OF END ITEM - TM-5-4310-378-140150
SECTION III. BASIC ISSUE ITEMS - TM-5-4310-378-140151
APPENDIX D. ADDITIONAL AUTHORIZATION LIST - TM-5-4310-378-140153
APPENDIX E. EXPENDABLE SUPPLIES AND MATERIALS LIST - TM-5-4310-378-140155
SECTION II. EXPENDABLE SUPPLIES AND MATERIALS LIST - TM-5-4310-378-140156
GLOSSARY - TM-5-4310-378-140157
GLOSSARY (CONT)
SECTION I. ABBREVIATIONS
SECTION II. DEFINITION OF UNUSUAL TERMS
SECTION II. DEFINITION OF UNUSUAL TERMS (CONT) - TM-5-4310-378-140161
SECTION II. DEFINITION OF UNUSUAL TERMS (CONT) - TM-5-4310-378-140162
TM-5-4310-378-14 Compressor Unit Reciprocating 5 CFM 175 PSI Gasoline Engine Driven Hand Truck Mounted Model Number Manual

Western Governors University

Privacy Statement
Press Release
Contact

Integrated Publishing, Inc. - A (SDVOSB) Service Disabled Veteran Owned Small Business