TM-5-4310-386-14 Compressor Reciprocating Air: Electric Motor Driven & CFM 175 PSI C & H Model 20-918 Manual

CHAPTER 1 INTRODUCTION - TM-5-4310-386-14_15
Section II. EQUIPMENT DESCRIPTION AND DATA - TM-5-4310-386-14_16
Figure 1-2. Location of Major Components. - TM-5-4310-386-14_17
1-9. Equipment Data. - TM-5-4310-386-14_18
Section III. PRINCIPLES OF OPERATION - TM-5-4310-386-14_19
Figure 1-3. Flow Diagram.
b. Normal Operation
CHAPTER 2 OPERATING INSTRUCTIONS - TM-5-4310-386-14_22
Figure 2-1. Control Panel Controls and Indicators.
Control or Indicator
Figure 2-2. Diesel Engine Controls and Indicators.
Section II. OPERATOR PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) - TM-5-4310-386-14_26
2-9.   Special Instructions.
Table 2-1. Operator Preventive Maintenance Checks and Services (PMCS). - TM-5-4310-386-14_28
Operator Preventive Maintenance Checks and Services (PMCS) (Cont). - TM-5-4310-386-14_29
Section III. OPERATION UNDER USUAL CONDITIONS - TM-5-4310-386-14_30
Figure 2-3. Pre-Operational Checks
2-12. Start-Up Procedures
Figure 2-4. Start-Up Procedures.
2-13. Shut-Down Procedures
Figure 2-5. Shut-Down Procedures.
Section IV. OPERATION UNDER UNUSUAL CONDITIONS - TM-5-4310-386-14_36
Prepare the blend in the tank
2-15. Operation in Extreme Heat
2-18. Operation in Salt Water Areas.
CHAPTER 3 OPERATOR MAINTENANCE - TM-5-4310-386-14_40
CHAPTER 4 UNIT MAINTENANCE - TM-5-4310-386-14_41
Section II. SERVICE UPON RECEIPT - TM-5-4310-386-14_42
b. Preliminary Service and Adjustment
Section III. LUBRICATION INSTRUCTIONS
c. Service.
Figure 4-1. Servicing Engine.
Figure 4-2. Servicing Engine Oil Filter.
Figure 4-3. Servicing Engine Oil Bath Air Filter
f. Compressor Oil.
Figure 4-4. Servicing Compressor Oil.
Figure 4-5. Servicing Engine Clutch.
Section IV. UNIT PREVENTIVE MAINTENANCE CHECK AND SERVICES (PMCS)
Table 4-1. Unit Preventive Maintenance Checks and Services (PMCS).
Unit Preventive Maintenance Checks and Services (PMCS). -cont - TM-5-4310-386-14_54
Unit Preventive Maintenance Checks and Services (PMCS). -cont - TM-5-4310-386-14_55
Unit Preventive Maintenance Checks and Services (PMCS). -cont - TM-5-4310-386-14_56
Unit Preventive Maintenance Checks and Services (PMCS). -cont - TM-5-4310-386-14_57
SYMPTOM INDEX - TM-5-4310-386-14_58
Table 4-2. Unit Troubleshooting Procedures
3. TEMPERATURE SHUTDOWN ACTIVATES.
4. ENGINE GIVES POOR PERFORMANCE.
5. ENGINE OIL PRESSURE ZERO OR TOO LOW
6. ENGINE OIL CONSUMPTION EXCESSIVE.
8. ENGINE SMOKES BLUE.
11. ENGINE OVERHEATS OR BACKFIRES.
13. BATTERY UNDERCHARGED (AMMETER INDICATES CONSTANT DISCHARGE)
17. COMPRESSOR WILL NOT LOAD
20. COMPRESSED AIR HAS OILY TASTE.
24. COMPRESSOR OUTPUT INSUFFICIENT.
Section VI. UNIT MAINTENANCE PROCEDURES - TM-5-4310-386-14_70
4-15. Beltguard.
Figure 4-6. Belt Guard, Replace.
4-16. Clutch Panel.
Figure 4-7. Clutch Panel, Replace.
4-17. Side Panel
Figure 4-8. Side Panel, Replace.
4-18. Top Tray.
Figure 4-9. Top Tray, Replace
4-19. Controls and Indicators .
Figure 4-10. Engine Oil Pressure Gage, Replace.
(2) Temperature gage.
Figure 4-12. Ammeter, Replace.
Figure 4-13. Hourmeter, Replace.
Figure 4-14. Start Switch, Replace.
Figure 4-15. Engine RUN/STOP Switch, Replace.
Figure 4-16. Relay Latch, Replace.
Figure 4-17. Switches (ON/OFF), Replace.
Figure 4-18. Indicator Light, Replace.
Controls and Indicators (Cont). - TM-5-4310-386-14_89
Figure 4-19. Throttle Control, Replace.
Controls and Indicators (Cont). - TM-5-4310-386-14_91
Figure 4-20. Solenoid, Replace.
4-20. Compressor Drive Belt and Pulleys
Figure 4-21. Compressor Drive Belt and Pulleys, Adjust.
b. Replace. - TM-5-4310-386-14_95
Figure 4-22. Compressor Drive Belt and Pulley, Replace.
4-21. Air Compressor Assembly
Figure 4-23. Air Compressor Assembly, Service (Oil Change).
Air Compressor Assembly (Cont). - TM-5-4310-386-14_99
Figure 4-24. Air Compressor Assembly, Service (Intercooler)
4-22. Compressor Air Intake Filter Assembly
Figure 4-25. Compressor Air Intake Filter Assembly, Replace.
4-23. Compressor Fanwheel Guard
Figure 4-26. Compressor Fanwheel Guard, Replace.
4-24. Compressor Flywheel/Fanwheel Assembly
Figure 4-27. Compressor Flywheel/Fanwheel Assembly, Replace.
b. Repair. - TM-5-4310-386-14_107
Figure 4-28. Compressor Flywheel/Fanwheel Assembly, Repair.
4-25. Compressor Drive Belt and Guard
Figure 4-29. Compressor Drive Belt, Adjust.
b. Replace. - TM-5-4310-386-14_111
Figure 4-30. Compressor Drive Belt and Guard, Replace
4-26. Fuel Tank
Figure 4-31. Fuel Tank, Replace.
(10) Apply teflon tape
4-27. Top Strap Assembly
Figure 4-32. Top Strap Assembly, Replace.
4-28. Bottom Strap Assembly
Figure 4-33. Bottom Strap Assembly, Replace
4-29. Engine Assembly
Figure 4-34. Engine Assembly, Service
b. Replace. - TM-5-4310-386-14_122
Figure 4-35. Engine Assembly, Removal (Sheet 1 of 5).
Figure 4-35. Engine Assembly, Removal (Sheet 2 of 5).
Figure 4-35. Engine Assembly, Removal (Sheet 3 of 5)
Figure 4-35. Engine Assembly, Removal (Sheet 4 of 5).
Figure 4-35. Engine Assembly, Removal (Sheet 5 of 5).
(2) Installation.
Figure 4-36. Engine Assembly, Installation (Sheet 1 of 5).
Figure 4-36. Engine Assembly, Installation (Sheet 2 of 5).
Figure 4-36. Engine Assembly, Installation (Sheet 3 of 5)
Figure 4-36. Engine Assembly, Installation (Sheet 4 of 5).
Figure 4-36. Engine Assembly, Installation (Sheet 5 of 5).
4-30. Fuel System.
Figure 4-37. Fuel System, Service.
4-31. Fuel Lines and Fittings.
Figure 4-38. Fuel Lines and Fittings, Replace (Sheet 1 of 2).
Fuel Lines and Fittings (Cont).
Figure 4-38. Fuel Lines and Fittings, Replace (Sheet 2 of 2)
4-32. Fuel Feed Pump.
Figure 4-39. Fuel Feed Pump, Replace.
b. Repair - TM-5-4310-386-14_142
Figure 4-40. Fuel Feed Pump, Repair.
4-33. Fuel Filter.
Figure 4-41. Fuel Filter, Replace.
4-34. Injector Lines.
Figure 4-42. Injector Lines, Replace.
4-35. Over Flow Return Line.
Figure 4-43. Over Flow Return Line, Replace.
4-36. Prefilter.
Figure 4-44. Prefilter, Replace.
4-37. Oil Bath Air Filter Assembly .
Figure 4-45. Oil Bath Air Filter Assembly, Service.
b. Replace.
Figure 4-46. Oil Bath Air Filter Assembly, Replace.
c. Repair.
Figure 4-47. Oil Bath Air Filter Assembly, Repair.
4-38. Air Intake Manifold
Figure 4-48. Air Intake Manifold, Replace.
4-39. Exhaust System
Figure 4-49. Exhaust System, Replace.
4-40. Engine V-Beltguard.
Figure 4-50. Engine V-Beltguard, Replace.
4-41. V-Belt.
Figure 4-51. V-Belts, Replace.
4-42. Cooling Air Ducting
Figure 4-52. Cooling Air Ducting, Replace
(16)    Install front plate
4-43. Wiring Harness.
Figure 4-53. Wiring Harness. Test (Sheet 2 of 2).
b. Replace. - TM-5-4310-386-14_171
Figure 4-54. Wiring Harness, Replace
4-44. Alternator.
Figure 4-55. Alternator, Test.
b. Adjust
Figure 4-56. Alternator, Adjust.
c. Replace.
Figure 4-57. Alternator, Replace.
4-45. Battery, Cover, and Cables.
Figure 4-58. Battery, Test.
b. Replace - TM-5-4310-386-14_181
Figure 4-59. Battery and Cables, Replace
4-46. Shutdown Device.
Figure 4-60. Shutdown Device, Replace
4-47. Starter.
Figure 4-61. Starter, Replace.
4-48. Starting Aid.
Figure 4-62. Starting Aid, Replace
b. Repair. - TM-5-4310-386-14_189
Figure 4-64. Reservoir, Replace.
(3) Replace hand pump.
Figure 4-65. Hand Pump, Replace
4-49. Oil Filter Assembly
Figure 4-66. Oil Filter Assembly, Service.
b. Replace. - TM-5-4310-386-14_195
Figure 4-67. Oil Filter Assembly, Replace.
4-50. Dipstick and Filler Cap
Figure 4-68. Dipstick and Filler Cap, Replace
4-51. Engine Lube Oil Cooler
Figure 4-69. Engine Lube Oil Cooler, Service.
b. Replace. - TM-5-4310-386-14_201
Figure 4-70. Engine Lube Oil Cooler, Replace
4-52. Rocker Covers.
Figure 4-71. Rocker Cover, Replace.
4-53. Engine Mounts
Figure 4-72. Engine Mounts, Replace
Section VII. UNIT LEVEL CLEANING PROCEDURES
4-58. Pre-Cleaning of Components or Piping
a. Cleaning Components or Assemblies
4-60.   Cleaning Method Trisodium Phosphate (TSP)
Table 4-3. TSP Cleaning Solution Volume - TM-5-4310-386-14_211
Table 4-4. Cleaning Solution Flow Rate - TM-5-4310-386-14_212
Table 4-5. Cleaning Agents Comparable with Soft Goods
4-62. Hydrocarbon Inspection and Analysis.
4-63. Documentation and Record Keeping
Section VIII. PREPARATION FOR STORAGE OR SHIPMENT
4-66. Preparation for Shipment.
CHAPTER 5 DIRECT SUPPORT MAINTENANCE - TM-5-4310-386-14_218
5-5. Direct Support Troubleshooting Procedures
Table 5-1. Direct Support Troubleshooting Procedures
5. SIGHT GLASS EXHIBITS AIR BUBBLES
8. CONDENSATE AUTOMATIC DRAIN NOT DRAINING (COLD WEATHER)
11. SAFETY VALVES BETWEEN STAGES RELEASING PRESSURE
17. ENGINE OIL PRESSURE ZERO OR TOO LOW
19. ENGINE SMOKES WHITE.
Section III. DIRECT SUPPORT MAINTENANCE PROCEDURES - TM-5-4310-386-14_226
5-7. Control Panel Assembly.
Figure 5-1. Control Panel, Replace.
b. Repair - TM-5-4310-386-14_229
Figure 5-2. Control Panel, Repair
5-8. Controls and Indicators.
Figure 5-3. Service Line Control Valve, Replace
(2) Service line pressure gage.
Figure 5-4. Service Line Pressure Gage, Replace.
(3) Pressure gage
Figure 5-5. Pressure Gage, Replace.
(4) Oil pressure gage
Figure 5-6. Oil Pressure Gage, Replace
(5) Service outlet.
Figure 5-7. Service Outlet, Replace
5-9. Compressor Assembly.
Figure 5-8. Compressor Assembly, Replace (Sheet 1 of 3)
(6) Loosen two coupling nuts
Figure 5-8. Compressor Assembly, Replace (Sheet 2 of 3).
Figure 5-8. Compressor Assembly, Replace (Sheet 3 of 3).
5-10. Lines and Fittings
Figure 5-9. Lines and Fittings, Removal (Sheet 1 of 6).
Lines and Fittings (Cont) - TM-5-4310-386-14_248
Figure 5-9. Lines and Fittings, Removal (Sheet 2 of 6)
Lines and Fittings (Cont). - TM-5-4310-386-14_250
Figure 5-9. Lines and Fittings, Removal (Sheet 3 of 6).
Lines and Fittings (C ont).
Figure 5-9. Lines and Fittings, Removal (Sheet 4 of 6).
Figure 5-9. Lines and Fittings, Removal (Sheet 5 of 6).
Figure 5-9. Lines and Fittings, Removal (Sheet 6 of 6).
(2) Installation.
Figure 5-10. Lines and Fittings, Installation (Sheet 1 of 6).
Lines and Fittings (Cont). - TM-5-4310-386-14_258
Figure 5-10. Lines and Fittings, Installation (Sheet 2 of 6).
Lines and Fittings (Cont). - TM-5-4310-386-14_260
Figure 5-10. Lines and Fittings, Installation (Sheet 3 of 6).
Figure 5-10. Lines and Fittings, Installation (Sheet 4 of 6).
Figure 5-10. Lines and Fittings, Installation (Sheet 5 of 6).
Figure 5-10. Lines and Fittings, Installation (Sheet 6 of 6).
5-11. Compressor Oil Pump and Supply Line
Figure 5-11. Compressor Oil Pump and Supply Line, Replace
5-12. Oil Pressure Regulator Valve and Oil Return Line
Figure 5-12. Oil Pressure Regulator Valve and Oil Return Line, Adjust.
b. Replace. - TM-5-4310-386-14_269
Figure 5-13. Oil Pressure Regulator Valve and Oil Return Line, Replace.
c. Repair. - TM-5-4310-386-14_271
Figure 5-14. Oil Pressure Regulator Valve and Oil Return Line, Repair.
5-13. Compressor Intercoolers and Aftercooler.
Figure 5-15. Compressor 1st Stage Intercooler, Replace.
Compressor Intercoolers and Aftercooler (Cont)
Figure 5-16. Compressor 2nd Stage Intercooler, Replace
Compressor Intercoolers and Aftercooler (Cont). - TM-5-4310-386-14_277
Figure 5-17. Compressor 3rd Stage Intercooler, Replace.
Compressor Intercoolers and Aftercooler (Cont). - TM-5-4310-386-14_279
Figure 5-18. Compressor Aftercooler, Replace.
5-14. Manifold and Safety Valve.
Figure 5-19. Manifold and Safety Valve (1st Stage), Replace.
5-15. Interfilter Heater Block Assembly.
Figure 5-20. Interfilter Heater Block Assembly, Replace
FOLLOW-ON MAINTENANCE - TM-5-4310-386-14_285
5-16. Interfilter Safety Valve.
Figure 5-21. Interfilter Safety Valves, Replace.
5-17. Interfilter Drain Valves.
Figure 5-22. Interfilter Drain Valves, Replace.
b. Repair.
Figure 5-23. Interfilter Drain Valves, Repair.
FOLLOW-ON MAINTENANCE - TM-5-4310-386-14_292
5-18. Interfilter 2nd and 3rd Stage Housing.
Figure 5-24. Interfilter 2nd and 3rd Stage Housing, Replace.
b. Repair. - TM-5-4310-386-14_295
Figure 5-25. Interfilter 2nd and 3rd Stage Housing, Repair.
5-19. Oil Water Separator Housing.
Figure 5-26. Oil Water Separator, Replace.
b. Repair - TM-5-4310-386-14_299
Figure 5-27. Oil Water Separator Housing, Repair.
5-20. Interfilter Heater Block.
Figure 5-28. Interfilter Heater Block, Replace.
5-21. 1st Stage Valve Head Assembly
Figure 5-29. 1st Stage Valve Head Assembly, Replace.
b. Repair - TM-5-4310-386-14_305
Figure 5-30. 1st Stage Valve Head Assembly, Repair.
(14) Install gasket
5-22. 2nd and 3rd Stage Valve Head Assembly.
Figure 5-31. 2nd and 3rd Stage Valve Head Assembly, Replace
b. Repair. - TM-5-4310-386-14_310
Figure 5-32. 2nd and 3rd Stage Valve Head Assembly, Repair.
(18) Apply Teflon tape to elbow
5-23. 4th Stage Valve Head Assembly.
Figure 5-33. 4th Stage Valve Head Assembly, Replace.
b. Repair. - TM-5-4310-386-14_315
Figure 5-34. 4th Stage Valve Head Assembly, Repair.
(15) Install discharge valve seat
5-24. Safety Valve.
Figure 5-35. Safety Valve, Replace.
5-25. Tension Pulley Assembly, Driving Gear and Eccentric Shaft Drive Gear
Figure 5-36. Tension Pulley Assembly, Driving Gear and Eccentric Shaft Drive Gear, Replace
b. Repair. - TM-5-4310-386-14_322
Figure 5-37. Tension Pulley Assembly, Driving Gear and Eccentric Shaft Drive Gear, Repair.
5-26. Air Purification Group.
Figure 5-38. Air Purification group, Service.
5-27. Purification Cylinders.
Figure 5-39. Purification Cylinders, Replace.
Purification Cylinders (Cont).
Figure 5-40. Purification Cylinders, Repair.
5-28. Pressure Maintaining Valve
Figure 5-41. Pressure Maintaining Valve, Replace.
b. Repair. - TM-5-4310-386-14_332
Figure 5-42. Pressure Maintaining Valve, Repair
5-29. Fuel Tank
Figure 5-43. Fuel Tank, Repair.
5-30. Fuel Injection Pump.
Figure 5-44. Fuel Injection Pump, Adjust (Sheet 1 of 2).
Fuel Injection Pump (Cont). - TM-5-4310-386-14_338
Figure 5-44. Fuel Injection Pump, Adjust (Sheet 2 of 2).
Fuel Injection Pump (Cont). - TM-5-4310-386-14_340
Figure 5-45. Fuel Injection Pump, Replace.
c. Repair. - TM-5-4310-386-14_342
Figure 5-46. Injection Pump, Repair (Sheet I of 3)
Fuel Injection Pump (Cont). - TM-5-4310-386-14_344
Figure 5-46. Injection Pump, Repair (Sheet 2 of 3)
Fuel Injection Pump (Cont). - TM-5-4310-386-14_346
Figure 5-46. Injection Pump, Repair (Sheet 3 of 3)
FOLLOW-ON MAINTENANCE - TM-5-4310-386-14_348
5-31. Engine Injectors
Figure 5-47. Engine Injectors, Replace.
5-32. Cooler Air Blower
Figure 5-48. Cooler Air Blower, Replace.
b. Repair. - TM-5-4310-386-14_353
Figure 5-49. Cooler Air Blower, Repair
5-33. Oil Pump
Figure 5-50. Oil Pump, Replace.
5-34. Lube Oil Line.
Figure 5-51. Lube Oil Line Assembly, Replace.
5-35. Flywheel and Clutch Carrier
Figure 5-52. Flywheel and Clutch Carrier, Replace.
b. Repair - TM-5-4310-386-14_361
Figure 5-53. Flywheel and Clutch Carrier, Repair.
5-36. Flywheel Housing Assembly
Figure 5-54. Flywheel Housing Assembly, Replace
5-37. Rear Cover
Figure 5-55. Rear Cover, Replace
5-38. Rocker Arms and Push Rods.
Figure 5-56. Rocker Arms and Push Rods, Replace
FOLLOW-ON MAINTENANCE - TM-5-4310-386-14_369
5-39. Push Rod Tubes.
Figure 5-57. Push Rod Tubes, Replace.
5-40. Cylinder Head Assembly
Figure 5-58. Cylinder Head, Adjust.
b. Replace - TM-5-4310-386-14_374
Figure 5-59. Cylinder Head, Replace.
Cylinder Head Assembly (Cont).
Figure 5-60. Cylinder Head, Repair
FOLLOW-ON MAINTENANCE - TM-5-4310-386-14_378
5-41. Valves.
Figure 5-61. Valves, Adjust
b. Replace - TM-5-4310-386-14_381
Figure 5-62. Valves, Replace.
5-42. Engine Cylinders.
Figure 5-63. Engine Cylinder, Replace.
5-43. Engine Piston and Rings.
Figure 5-64. Engine Piston and Rings, Replace.
b. Repair. - TM-5-4310-386-14_387
Figure 5-65. Engine Piston and Rings, Repair.
FOLLOW-ON MAINTENANCE - TM-5-4310-386-14_389
5-44. Engine Connecting Rod
Figure 5-66. Engine Connecting Rod, Replace.
b. Repair. - TM-5-4310-386-14_392
Figure 5-67. Engine Connecting Rod, Repair.
(15) Install connecting rod
5-45. Engine Front Cover
Figure 5-68. Engine Front Cover, Replace
b. Repair. - TM-5-4310-386-14_397
Figure 5-69. Engine Front Cover, Repair
5-46. Access Covers
Figure 5-70. Access Cover, Replace.
5-47. Power Take-Off (PTO) Assembly
Figure 5-71. PTO Clutch, Adjust.
Replace - TM-5-4310-386-14_403
Figure 5-72. PTO, Replace
5-48. Clutch Assembly
Figure 5-73. Clutch Assembly, Replace.
5-49. Inner Frame
Figure 5-74. Inner Frame, Replace.
b. Repair - TM-5-4310-386-14_409
Figure 5-75. Inner Frame, Repair.
5-50. Outer Frame
Figure 5-76. Outer Frame, Replace
b. Repair. - TM-5-4310-386-14_413
Figure 5-77. Outer Frame, Repair.
CHAPTER 6 GENERAL SUPPORT MAINTENANCE
Section II. GENERAL SUPPORT TROUBLESHOOTING
Table 6-1. General Support Troubleshooting Procedures - TM-5-4310-386-14_417
General Support Troubleshooting Procedures -cont - TM-5-4310-386-14_418
General Support Troubleshooting Procedures -cont - TM-5-4310-386-14_419
6-7. 1st Stage Cylinder and Piston
Figure 6-1. 1st Stage Cylinder and Piston, Replace.
1st Stage Cylinder and Piston (Cont).
Figure 6-2. 1st Stage Cylinder and Piston, Repair.
6-8. 2nd Stage Cylinder and Piston.
Figure 6-3. 2nd Stage Cylinder and Piston, Replace.
2nd Stage Cylinder and Piston (Cont).
Figure 6-4. 2nd Stage Cylinder and Piston, Repair.
FOLLOW-ON MAINTENANCE - TM-5-4310-386-14_428
6-9. 3rd Stage Cylinder and Piston.
Figure 6-5. 3rd Stage Cylinder and Piston, Replace
b. Repair. - TM-5-4310-386-14_431
Figure 6-6. 3rd Stage Cylinder and Piston, Repair
FOLLOW-ON MAINTENANCE - TM-5-4310-386-14_433
6-10. 4th Stage Cylinder and Piston.
Figure 6-7. 4th Stage Cylinder and Piston, Replace.
4th Stage Cylinder and Piston (Cont).
Figure 6-8. 4th Stage Cylinder and Piston, Repair
6-11. Compressor Upper Crankcase.
Figure 6-9. Upper Crankcase, Replace
6-12. Crankcase Cover
Figure 6-10. Crankcase Front Cover Assembly, Replace.
Crankcase Cover (Cont).
Figure 6-11. Crankcase Front Cover Assembly, Repair
6-13. Compressor Crankshaft Assembly.
Figure 6-12. Compressor Crankshaft Assembly, Replace
Compressor Crankshaft Assembly (Cont).
Figure 6-13. Compressor Crankshaft Assembly, Repair
6-14. Compressor Lower Crankcase.
Figure 6-14. Compressor Lower Crankcase, Replace.
Compressor Lower Crankcase (Cont).
Figure 6-15. Compressor Lower Crankcase, Repair.
6-15. Compressor Eccentric Shaft.
Figure 6-16. Compressor Eccentric Shaft, Replace.
b. Repair - TM-5-4310-386-14_454
Figure 6-17. Compressor Eccentric Shaft, Repair.
6-16. Alternator
Figure 6-18. Alternator, Disassemble.
Alternator (Cont).
Figure 6-19. Alternator, Assemble.
6-17. Starter.
Figure 6-20. Starter, Disassembly.
Starter (Cont). - TM-5-4310-386-14_462
Figure 6-21. Starter, Assembly.
6-18. Crankshaft.
Figure 6-22. Crankshaft, Removal.
Crankshaft (Cont).
Figure 6-23. Crankshaft, Inspections.
FOLLOW-ON MAINTENANCE - TM-5-4310-386-14_468
Figure 6-24. Crankshaft, Installation
6-19. Camshaft and Cover
Figure 6-25. Engine Camshaft and Valve Lifter Tappets, Replace.
FOLLOW-ON MAINTENANCE - TM-5-4310-386-14_472
6-20. Crankcase.
Figure 6-26. Engine Crankcase, Replace.
6-21. Power Take-Off Assembly.
Figure 6-27. Power Take-Off Assembly, Repair.
FOLLOW-ON MAINTENANCE - TM-5-4310-386-14_477
6-22. Clutch Assembly .
Figure 6-28. Clutch Assembly, Repair
Clutch Assembly (Cont). - TM-5-4310-386-14_480
APPENDIX A REFERENCES - TM-5-4310-386-14_481
APPENDIX B MAINTENANCE ALLOCATION CHART - TM-5-4310-386-14_482
B-3. Column Entries
B-4. Tool and Test Equipment Requirements
Section II. MAINTENANCE ALLOCATION CHART - TM-5-4310-386-14_485
MAINTENANCE ALLOCATION CHART -cont - TM-5-4310-386-14_486
MAINTENANCE ALLOCATION CHART -cont - TM-5-4310-386-14_487
MAINTENANCE ALLOCATION CHART -cont - TM-5-4310-386-14_488
MAINTENANCE ALLOCATION CHART -cont - TM-5-4310-386-14_489
MAINTENANCE ALLOCATION CHART -cont - TM-5-4310-386-14_490
MAINTENANCE ALLOCATION CHART -cont - TM-5-4310-386-14_491
MAINTENANCE ALLOCATION CHART -cont - TM-5-4310-386-14_492
MAINTENANCE ALLOCATION CHART -cont - TM-5-4310-386-14_493
MAINTENANCE ALLOCATION CHART -cont - TM-5-4310-386-14_494
Section III. TOOL AND TEST EQUIPMENT REQUIREMENTS - TM-5-4310-386-14_495
TOOL AND TEST EQUIPMENT REQUIREMENTS -cont - TM-5-4310-386-14_496
TOOL AND TEST EQUIPMENT REQUIREMENTS -cont - TM-5-4310-386-14_497
TOOL AND TEST EQUIPMENT REQUIREMENTS -cont - TM-5-4310-386-14_498
TOOL AND TEST EQUIPMENT REQUIREMENTS -cont - TM-5-4310-386-14_499
TOOL AND TEST EQUIPMENT REQUIREMENTS -cont - TM-5-4310-386-14_500
TOOL AND TEST EQUIPMENT REQUIREMENTS -cont - TM-5-4310-386-14_501
Section IV. REMARKS - TM-5-4310-386-14_502
APPENDIX C COMPONENTS OF END ITEM AND BASIC ISSUE ITEMS LISTS - TM-5-4310-386-14_503
Section II. COMPONENTS OF END ITEMS - TM-5-4310-386-14_504
Description Usable on Code - TM-5-4310-386-14_505
Section III. BASIC ISSUE ITEMS - TM-5-4310-386-14_506
BASIC ISSUE ITEMS -cont
Description Usable on Code - TM-5-4310-386-14_508
APPENDIX D ADDITIONAL AUTHORIZATION LIST - TM-5-4310-386-14_509
APPENDIX E EXPENDABLE/DURABLE SUPPLIES AND MATERIALS LIST - TM-5-4310-386-14_510
Section II. EXPENDABLE/DURABLE SUPPLIES AND MATERIALS LIST - TM-5-4310-386-14_511
EXPENDABLE/DURABLE SUPPLIES AND MATERIALS LIST -cont
APPENDIX F TORQUE LIMITS - TM-5-4310-386-14_513
b Engine.
c. Tightening Heavy-Duty Bolts (Screws and Nuts) on Deutz Engine.
Table F-2. Torque Specification for Bolts and Nuts on Deutz Engine.

Western Governors University

Privacy Statement
Press Release
Contact

Integrated Publishing, Inc. - A (SDVOSB) Service Disabled Veteran Owned Small Business