TM 5-4310-451-14
3-8. STORAGE BATTERY INSPECTION.
WARNING
Remove all Jewelry such as dog tags, rings, bracelets, etc. If Jewelry or disconnected battery
ground cable contacts battery terminal, a direct short will result. Failure to follow proper
disconnection procedures will result in serious injury or death to personnel or equipment
damage.
Battery acid (electrolyte) is extremely dangerous. Always wear goggles and rubber gloves
when performing battery checks or inspections. Serious injury to personnel will result if
battery acid contacts skin or eyes.
DO NOT perform battery system checks or inspections while smoking or near fire, flames, or
sparks. Batteries may explode, causing serious injury or death to personnel.
NOTE
Refer to TM 9-6140-200-14 for additional instructions on inspecting batteries.
Repeat steps a through c for each battery.
a.
Visually inspect battery (1) for damage and corrosion. Notify your supervisor if damage or corrosion is
present.
b.
Inspect two battery terminals (3) for looseness or damage. Notify your supervisor if battery terminals are
loose or damaged.
c.
Remove six vent caps (2) from battery (1) and check fluid level. Notify your supervisor if fluid level is low.
3-17/(3-18 Blank)
