TM 9-4310-397-14
(4)
Roadside Doors and Panel.
(a)
Install door latches (Figure 4-19, 1) and secure with hex nuts on both doors.
(b)
Install door holders (3) and secure with four rivets (2) (item 42, appendix H) on both doors.
(c)
Install door hinge (5) and secure to left door (7) with three rivets (8) (item 63, appendix H).
(d)
Install door hinge (10) and secure to right door (11) with five rivets (12) (item 63, appendix H).
(e)
Fabricate insulation panel (17) per the following:
1
Cut insulation panel per appendix F.
NOTE
Paper backing on insulation panel must be removed when installed.
2
Carefully peel paper backing away from around insulation panel edge.
3
Cover exposed insulation panel edge with foil back tape (item 9, section II, appendix E) folded over
edges. Be sure tape is under paper backing on insulation panel.
WARNING
Metal pins pierce insulation panels when installed. Injury to hands can result if care is not taken
when installing insulation panels.
(f)
Remove paper backing from insulation panel and install with sticky side against sheet metal panel.
Carefully locate pins and install new clips (16) (item 6, appendix H).
(g)
Install doors (7) and (11) onto panel (6) and secure with ten rivets (4) and (9) (item 63, appendix H).
(h)
Install caution plate (14) with four rivets (13) (item 55, appendix H).
(i)
Peel backing off decal (15) and position on road side panel (6).
(j)
Install panel assembly (Figure 4-18, 5) and secure with twenty one hex head screws (1) and flat washers
(2).
(k)
Install five hex head screws (3), flat washers (4).
(5)
Curbside Doors and Panel.
(a)
Install door latches (Figure 4-17, 1) and secure with hex nuts on both doors.
(b)
Install door holders (3) and secure each with eight rivets (2) (item 42, appendix H) onto doors.
(c)
Install door hinge (5) and secure to left door (6) with seven rivets (4) (item 63, appendix H).
(d)
Install door hinge (9) and secure to right door (10) with seven rivets (8) (item 63, appendix H).
(e)
Install doors onto panel (12) and secure with eight rivets (7) and (11) (item 63, appendix H).
4-85
